Radio Flyer-84 Grand Waggy

Show off your FSJ photos and videos!
Post Reply
User avatar

Tatsadasayago
Posts: 3684
Joined: Thu Aug 28, 2014 2:22 pm
Location: Sacramento, CA

Re: Radio Flyer-84 Grand Waggy

Post by Tatsadasayago »

Nice progress!
As far as the coolant temp goes, you can easily test if the gauge is operating properly by grounding the wire and looking at your gauge.
1977 Cherokee Chief - The Blair Jeep Project III
A collection of parts flying in close formation
User avatar

Topic author
dodgerammit
Posts: 1434
Joined: Wed Jan 11, 2017 11:20 pm
Location: Middle TN

Re: Radio Flyer-84 Grand Waggy

Post by dodgerammit »

Tatsadasayago wrote:Nice progress!
As far as the coolant temp goes, you can easily test if the gauge is operating properly by grounding the wire and looking at your gauge.
What should the gauge do? Go full hot?
84 Grand Waggy-Radio Flyer (Garnet Red/3M Ebony Metallic woodgrain, with honey interior) AMC 360 :cry: 2004 4.8LS/Advance Adapter/727/242 D44/AMC20 Serehill tailgate and headlight harnesses :fsj: Ongoing thread-viewtopic.php?t=11897

92 Wrangler Islander 4.0/32RH/231 D30/D35 RHD
User avatar

Tatsadasayago
Posts: 3684
Joined: Thu Aug 28, 2014 2:22 pm
Location: Sacramento, CA

Re: Radio Flyer-84 Grand Waggy

Post by Tatsadasayago »

Yes. I suggest you have someone sitting at the wheel when you ground the sender wire. (Or ground it with the key off then briefly energize the system) You don't want to leave it grounded any longer than you have to as it can overheat the gauge windings.
1977 Cherokee Chief - The Blair Jeep Project III
A collection of parts flying in close formation
User avatar

Topic author
dodgerammit
Posts: 1434
Joined: Wed Jan 11, 2017 11:20 pm
Location: Middle TN

Re: Radio Flyer-84 Grand Waggy

Post by dodgerammit »

Thanks!

I grounded, then switched the key on. Took a few seconds like the other gauges, but made it to full hot. Guess I'm due to replace the sender itself.
84 Grand Waggy-Radio Flyer (Garnet Red/3M Ebony Metallic woodgrain, with honey interior) AMC 360 :cry: 2004 4.8LS/Advance Adapter/727/242 D44/AMC20 Serehill tailgate and headlight harnesses :fsj: Ongoing thread-viewtopic.php?t=11897

92 Wrangler Islander 4.0/32RH/231 D30/D35 RHD
User avatar

Tatsadasayago
Posts: 3684
Joined: Thu Aug 28, 2014 2:22 pm
Location: Sacramento, CA

Re: Radio Flyer-84 Grand Waggy

Post by Tatsadasayago »

Easy Peazy!

Well done.
1977 Cherokee Chief - The Blair Jeep Project III
A collection of parts flying in close formation
User avatar

Topic author
dodgerammit
Posts: 1434
Joined: Wed Jan 11, 2017 11:20 pm
Location: Middle TN

Re: Radio Flyer-84 Grand Waggy

Post by dodgerammit »

Another thread I asked about the idle issues. It was mentioned to check carb mounting stud tightness.
Yep. Three of the four nuts were loose. One was so loose, I turned it a full turn by hand when tightening. Idle much better. at least no more bog/surge while cruising. No more fear of stalling at stop signs either.

Sender replaced. Gauge shows low-mid green sweep at operating temp. Good to go!

Driving and enjoying this thing more
84 Grand Waggy-Radio Flyer (Garnet Red/3M Ebony Metallic woodgrain, with honey interior) AMC 360 :cry: 2004 4.8LS/Advance Adapter/727/242 D44/AMC20 Serehill tailgate and headlight harnesses :fsj: Ongoing thread-viewtopic.php?t=11897

92 Wrangler Islander 4.0/32RH/231 D30/D35 RHD
User avatar

Topic author
dodgerammit
Posts: 1434
Joined: Wed Jan 11, 2017 11:20 pm
Location: Middle TN

Re: Radio Flyer-84 Grand Waggy

Post by dodgerammit »

Well, the erratic idle issues have slowly ebbed away with a good bit of driving. I've actually turned the idle down from where I had it set at a higher setting to prevent stalling. I think the float was possibly sticking. Driving fine now. The last week has seen about 250miles. Last fill up today (included 150 miles of highway driving to see the eclipse) netted 14.1mpg avg! Wife enjoys taking it out for cruises now that it is proving more reliable. :D
84 Grand Waggy-Radio Flyer (Garnet Red/3M Ebony Metallic woodgrain, with honey interior) AMC 360 :cry: 2004 4.8LS/Advance Adapter/727/242 D44/AMC20 Serehill tailgate and headlight harnesses :fsj: Ongoing thread-viewtopic.php?t=11897

92 Wrangler Islander 4.0/32RH/231 D30/D35 RHD
User avatar

Topic author
dodgerammit
Posts: 1434
Joined: Wed Jan 11, 2017 11:20 pm
Location: Middle TN

Re: Radio Flyer-84 Grand Waggy

Post by dodgerammit »

Did the front brakes today. Repacked wheel bearings. Replaced a missing spindle bearing.
84 Grand Waggy-Radio Flyer (Garnet Red/3M Ebony Metallic woodgrain, with honey interior) AMC 360 :cry: 2004 4.8LS/Advance Adapter/727/242 D44/AMC20 Serehill tailgate and headlight harnesses :fsj: Ongoing thread-viewtopic.php?t=11897

92 Wrangler Islander 4.0/32RH/231 D30/D35 RHD
User avatar

Topic author
dodgerammit
Posts: 1434
Joined: Wed Jan 11, 2017 11:20 pm
Location: Middle TN

Re: Radio Flyer-84 Grand Waggy

Post by dodgerammit »

Been DDing the Waggy for a week while my T/A is in paint. driving to a weekend job I had lined up, I passed a local car show site. The attendant seen me coming and was waving me in. The most perplexed look on her face as I smiled, waved and drove right by. :lol:
84 Grand Waggy-Radio Flyer (Garnet Red/3M Ebony Metallic woodgrain, with honey interior) AMC 360 :cry: 2004 4.8LS/Advance Adapter/727/242 D44/AMC20 Serehill tailgate and headlight harnesses :fsj: Ongoing thread-viewtopic.php?t=11897

92 Wrangler Islander 4.0/32RH/231 D30/D35 RHD
User avatar

Topic author
dodgerammit
Posts: 1434
Joined: Wed Jan 11, 2017 11:20 pm
Location: Middle TN

Re: Radio Flyer-84 Grand Waggy

Post by dodgerammit »

Nights getting cooler. Getting off at midnight means I need 100% functionality in the heat/defrost dept. Temperature was there, but the switching wasn't. Knew I had a vacuum issue not reaching the flapper door. Vacuum ball underhood not hooked to vacuum. Didn't need cruise right now, so I cut the hose and looped it to the ball. I can tee it back in later.

Fired up the 360, switched on the heat and defrost, and this thing is awesome!
84 Grand Waggy-Radio Flyer (Garnet Red/3M Ebony Metallic woodgrain, with honey interior) AMC 360 :cry: 2004 4.8LS/Advance Adapter/727/242 D44/AMC20 Serehill tailgate and headlight harnesses :fsj: Ongoing thread-viewtopic.php?t=11897

92 Wrangler Islander 4.0/32RH/231 D30/D35 RHD
User avatar

Topic author
dodgerammit
Posts: 1434
Joined: Wed Jan 11, 2017 11:20 pm
Location: Middle TN

Re: Radio Flyer-84 Grand Waggy

Post by dodgerammit »

Took the Waggy out last weekend and hauled the nephews around to check out Christmas lights. Had a blast. My hometown had Main St. decorated nicely.
Image
Another mileage update. Filled up today. 15.3 average on winter fuel!!!
84 Grand Waggy-Radio Flyer (Garnet Red/3M Ebony Metallic woodgrain, with honey interior) AMC 360 :cry: 2004 4.8LS/Advance Adapter/727/242 D44/AMC20 Serehill tailgate and headlight harnesses :fsj: Ongoing thread-viewtopic.php?t=11897

92 Wrangler Islander 4.0/32RH/231 D30/D35 RHD
User avatar

Topic author
dodgerammit
Posts: 1434
Joined: Wed Jan 11, 2017 11:20 pm
Location: Middle TN

Re: Radio Flyer-84 Grand Waggy

Post by dodgerammit »

Fantastic weekend. Located a mid 70s Waggy in a small boneyard a few miles away.

Scored a piece of stainless rear window trim to replace the cheap, yellowed plastic door trim from the factory. Drilled out 2 rivets and it was mine.
Also snagged a 2nd set of rear pillar trim (3 piece stuff) to replace my hammered set.
Wife noticed it had a receiver hitch. A Valley model. Was afraid it was as rusty as the rest of the Jeep.

Turns out, the bolts were still clean as was the hitch. Actually, really clean! Must have been installed late in the game.

Was able to use my 3/8" ratchet and a boxed/open combo to remove it. No breaker bar needed was a plus!

Now, I have a way to pull a small utility trailer to haul lawnmowers or parts.

Scored it all for $95!

Just finished installing the last item (hitch) tonight.

4 days of driving the Jeep. Averaging 14mpg, even with stop and go rush hour city traffic of a nearby sprawl.
84 Grand Waggy-Radio Flyer (Garnet Red/3M Ebony Metallic woodgrain, with honey interior) AMC 360 :cry: 2004 4.8LS/Advance Adapter/727/242 D44/AMC20 Serehill tailgate and headlight harnesses :fsj: Ongoing thread-viewtopic.php?t=11897

92 Wrangler Islander 4.0/32RH/231 D30/D35 RHD
User avatar

Topic author
dodgerammit
Posts: 1434
Joined: Wed Jan 11, 2017 11:20 pm
Location: Middle TN

Re: Radio Flyer-84 Grand Waggy

Post by dodgerammit »

Was recently contacted on fakebook by the seller of the Jeep. He had located the other roof rack he had in storage. Nobody had answered his ad, so he told me to come by and pick it up.

It is a newer style (Chrysler era) and is in great shape with aluminum tear drop cross bars. Cleaned it up and have it in storage.

Also have a tentative time at a new body shop (same guys that did my T/A) to get the Waggy in to swap out the bad hood and fender and respray.

While it is there, I'll have them pull the glass so the dash can be swapped.
84 Grand Waggy-Radio Flyer (Garnet Red/3M Ebony Metallic woodgrain, with honey interior) AMC 360 :cry: 2004 4.8LS/Advance Adapter/727/242 D44/AMC20 Serehill tailgate and headlight harnesses :fsj: Ongoing thread-viewtopic.php?t=11897

92 Wrangler Islander 4.0/32RH/231 D30/D35 RHD
User avatar

Topic author
dodgerammit
Posts: 1434
Joined: Wed Jan 11, 2017 11:20 pm
Location: Middle TN

Re: Radio Flyer-84 Grand Waggy

Post by dodgerammit »

In the middle of repairing my power door lock circuit by converting the system to work on relays.

Read it here:http://www.fsjnetwork.com/forum/viewtop ... 11&t=14233
84 Grand Waggy-Radio Flyer (Garnet Red/3M Ebony Metallic woodgrain, with honey interior) AMC 360 :cry: 2004 4.8LS/Advance Adapter/727/242 D44/AMC20 Serehill tailgate and headlight harnesses :fsj: Ongoing thread-viewtopic.php?t=11897

92 Wrangler Islander 4.0/32RH/231 D30/D35 RHD
User avatar

Topic author
dodgerammit
Posts: 1434
Joined: Wed Jan 11, 2017 11:20 pm
Location: Middle TN

Re: Radio Flyer-84 Grand Waggy

Post by dodgerammit »

Image
84 Grand Waggy-Radio Flyer (Garnet Red/3M Ebony Metallic woodgrain, with honey interior) AMC 360 :cry: 2004 4.8LS/Advance Adapter/727/242 D44/AMC20 Serehill tailgate and headlight harnesses :fsj: Ongoing thread-viewtopic.php?t=11897

92 Wrangler Islander 4.0/32RH/231 D30/D35 RHD

Cheapthrills
Posts: 632
Joined: Wed Nov 02, 2016 7:09 am
Location: Sedalia colorado

Re: Radio Flyer-84 Grand Waggy

Post by Cheapthrills »

I don't think that's gonna work for you....

87 grand Wagoneer mostly stock
90 grand Wagoneer (stalled 5.3 project)
User avatar

Topic author
dodgerammit
Posts: 1434
Joined: Wed Jan 11, 2017 11:20 pm
Location: Middle TN

Re: Radio Flyer-84 Grand Waggy

Post by dodgerammit »

Finished the door lock wiring. Gotta replace one actuator. Starting on power windows now.
Thread here:
http://www.fsjnetwork.com/forum/viewtop ... 11&t=14293
84 Grand Waggy-Radio Flyer (Garnet Red/3M Ebony Metallic woodgrain, with honey interior) AMC 360 :cry: 2004 4.8LS/Advance Adapter/727/242 D44/AMC20 Serehill tailgate and headlight harnesses :fsj: Ongoing thread-viewtopic.php?t=11897

92 Wrangler Islander 4.0/32RH/231 D30/D35 RHD
User avatar

fulsizjeep
Moderator
Posts: 5012
Joined: Sun Nov 06, 2011 7:21 am
Location: Fruitville, FL
Contact:

Re: Radio Flyer-84 Grand Waggy

Post by fulsizjeep »

220, 221, whatever it takes! :-bd (great pic)

What is that loopy thing at the gas cap?
Flint Boardman
88 GW, 401/727/208, 5" lift, D44s/4.10s/locked up, 35s
https://jubileejeeps.org/quadratrac
User avatar

Topic author
dodgerammit
Posts: 1434
Joined: Wed Jan 11, 2017 11:20 pm
Location: Middle TN

Re: Radio Flyer-84 Grand Waggy

Post by dodgerammit »

fulsizjeep wrote:220, 221, whatever it takes! :-bd (great pic)

What is that loopy thing at the gas cap?
This loopy thing?

Image

Image

Keeps me from laying the cap on the roof and forgetting it when filling up. :mrgreen:
84 Grand Waggy-Radio Flyer (Garnet Red/3M Ebony Metallic woodgrain, with honey interior) AMC 360 :cry: 2004 4.8LS/Advance Adapter/727/242 D44/AMC20 Serehill tailgate and headlight harnesses :fsj: Ongoing thread-viewtopic.php?t=11897

92 Wrangler Islander 4.0/32RH/231 D30/D35 RHD
User avatar

fulsizjeep
Moderator
Posts: 5012
Joined: Sun Nov 06, 2011 7:21 am
Location: Fruitville, FL
Contact:

Re: Radio Flyer-84 Grand Waggy

Post by fulsizjeep »

Cool. I was hoping the Jeep did not have worms. :o
Flint Boardman
88 GW, 401/727/208, 5" lift, D44s/4.10s/locked up, 35s
https://jubileejeeps.org/quadratrac
Post Reply